+008616696028525
2005-2-9 Computational results are compared to blending experiments of monodisperse and bidisperse systems using spherical glass beads in a 1:1 scale. Although some discrepancies were observed, DEM simulations illustrated good agreement with experimentally measured mixing and segregation rates for different fill levels and loading conditions.
Inquire now2005-3-1 In this paper, a GPU-based DEM software is tested in large-scale simulation of a tote blender by comparing with experiment data from literature
Inquire nowExperimental and computational investigation of mixing and segregation of granular material in a tote blender was carried out. The discrete element method (DEM) was used to simulate flow of spherical, free-flowing particles where the results of the computations were compared to blending. Computational results are compared to blending experiments of monodisperse and bidisperse
Inquire now2017-2-1 Results from Santos et al. [130] at 2.31 rad/sKarunarathne et al. [134] modelled the behaviour of an unspecified powder in a rotary drum and achieved a
Inquire now2005-10-1 The mass fraction of rice husk particles decreases in the bottom and increases at the upper regime of bed. Within 10 s almost complete segregation of rice husk and sand particles is predicted in the bed. Download : Download full-size image; Fig. 4. Segregation patterns of binary mixture of R-S360 at the superficial gas velocity of 0.58 m/s.
Inquire now2022-3-1 For the 5 cm experiments, the segregation index reaches its minimum level at experimental progress 0.8 and then starts to increase just before the end of the test run; i.e. towards the end of the experimental run the maximum level of mixing (lowest segregation index) is reached and segregation of the yellow particles towards the grate bottom ...
Inquire now2019-5-31 The mixing and segregation behaviour of binary solid mixtures has been extensively studied through various experiments, while accurate CFD simulations are difficult to achieve due to process complexity and a lack of reliable constitutive relations.
Inquire now2022-3-5 Two moving modes show bridging at the beginning of the experiments, an effect that could be reproduced by the DEM simulations. The influence of the modes and their specific parameters on segregation indices, a mixing rate and a
Inquire now2022-4-1 Researches on solids mixing and segregation are of great significance for the operation and design of fluidized bed reactors. In this paper, the local and global mixing and segregation characteristics of binary mixtures were investigated in a gas–solid fluidized bed by computational fluid dynamics-discrete element method (CFD-DEM) coupled approach.
Inquire now2017-2-1 Results from Santos et al. [130] at 2.31 rad/sKarunarathne et al. [134] modelled the behaviour of an unspecified powder in a rotary drum and achieved a qualitative agreement with experimental ...
Inquire now2005-10-1 Mixing and segregation characteristics of biomass particles are of practical importance because the in-bed combustion efficiency of
Inquire nowThe increase in the solid‐solid drag further improved the simulation results. AB - The mixing and segregation behaviour of binary solid mixtures has been extensively studied through various experiments, while accurate CFD simulations are difficult to achieve due to process complexity and a lack of reliable constitutive relations.
Inquire now2019-5-31 The mixing and segregation behaviour of binary solid mixtures has been extensively studied through various experiments, while accurate CFD simulations are difficult to achieve due to process complexity and a lack of reliable constitutive relations.
Inquire now2020-1-1 The mixing and segregation behaviour of binary solid mixtures has been extensively studied through various experiments, while accurate
Inquire now2006-5-1 Characterization of Mixing. Several methods to quantify the time dependent degree of mixing or segregation have been described in literature 1,2,4,6,7,38, 39 Here we use a
Inquire nowDOI: 10.1016/J.CES.2013.04.035 Corpus ID: 96647001; Experimental investigation of solid mixing and segregation in a tetrapodal blender @article{Alizadeh2013ExperimentalIO, title={Experimental investigation of solid mixing and segregation in a tetrapodal blender}, author={Ebrahim Alizadeh and Habibollah Hajhashemi and François Bertrand and Jamal
Inquire nowA proper understanding of the segregation and mixing behaviour of polydisperse systems is crucial for industrial operation and process optimization. The segregation and mixing behaviour of binary particles has been extensively investigated through various experiments. [1–8] It is commonly observed that heavier and
Inquire now2021-2-20 Abstract Mixing and segregation of binary mixtures of freely-falling grains are demonstrated in a cylindrical pipe with an obstacle. Previously, the same setup was used to spatially focus monodisperse granular materials. As each grain is dropped one at a time from a random position at the entrance of the cylindrical pipe, it may collide with a steady or
Inquire now2020-9-17 Mechanical flow and segregation phenomena within a bed composed of milli-metric size spherical beads rotated in a horizontal drum were investigated. The beads population was bi-dispersed, with two kinds of binary (half by half) compositions: a bi-size bed with two different sizes and a bi-density bed with two different densities. The distributions of the beads were
Inquire nowThe presence of a hopper and bin section, as well as the axial offset proved to introduce greater axial mixing rates that would be expected from pure dispersion. Vibrated experiments showed better agreement than not-vibrated experiments, indicating that modeling of friction forces needs to be further improved to enhance the accuracy of DEM methods.
Inquire nowThe mixing and segregation behaviour of binary solid mixtures has been extensively studied through various experiments, while accurate CFD simulations are difficult to achieve due to process complexity and a lack of reliable constitutive relations. In this study, CFD simulations of a dense fluidized bed with glass and polystyrene particles were performed in order to identify a
Inquire now2007-11-8 Toggle main menu visibility. Join; Sign in; Toggle communities menu visibility Communities
Inquire now2009-5-5 Simulation parameters viz. solution technique, grid, maximum packing fraction and operating conditions like gas velocity were each investigated for the relative effects on particle mixing and segregation. Good agreement of solid volume fraction profile was obtained between the experimental results and simulation results for regular particles
Inquire nowDOI: 10.1016/J.CES.2013.04.035 Corpus ID: 96647001; Experimental investigation of solid mixing and segregation in a tetrapodal blender @article{Alizadeh2013ExperimentalIO, title={Experimental investigation of solid mixing and segregation in a tetrapodal blender}, author={Ebrahim Alizadeh and Habibollah Hajhashemi and François Bertrand and Jamal
Inquire nowIn this paper, the dynamics of a transverse plane of a rotary coating disk of a binary mixture system comprising sand and urea particles were simulated using the two-fluid model along with the kinetic theory of granular flow in Fluent 19.1. Although some parameters relating to the material properties and size of the rotary coating disk have been researched, the effects of
Inquire nowDOI: 10.1016/J.POWTEC.2006.01.018 Corpus ID: 95473961; A study of the mixing and segregation mechanisms in the Bohle Tote blender via DEM simulations @article{Arratia2006ASO, title={A study of the mixing and segregation mechanisms in the Bohle Tote blender via DEM simulations}, author={Paulo E. Arratia and Nhat-Hang P. Duong and
Inquire now2021-2-20 Abstract Mixing and segregation of binary mixtures of freely-falling grains are demonstrated in a cylindrical pipe with an obstacle. Previously, the same setup was used to spatially focus monodisperse granular materials. As each grain is dropped one at a time from a random position at the entrance of the cylindrical pipe, it may collide with a steady or
Inquire now2018-5-1 3-D Tote blender - mixing •Compared with published experiments of binary mixing of glass beads in an industrial-scale Tote blender from Sudah et al. (2005, AIChE J., Vol. 51) •All the parameters were calibrated from independent experiments •Predictions of the mixing rate (relative standard deviation, RSD) from the multi-scale
Inquire now2008-11-4 An entropy method quantifies the overall degree of mixing, while density and velocity plots are used to analyze the local properties of the granular bed. The percolation mechanism may provide a qualitative explanation for the distinct segregation processes, and for the transient mixing in nonradially segregated beds.
Inquire now